ACs are generally prepared using natural resources, such as wood, coal, nutshells, ... The potassium (K) only increased in SACC due to the KOH activation process. The various pretreatment processes were carried out in this study, and the reason to choose the process was summarized in Supplementary Table S3 [23,24]. The expected effects and ...
Optimum process conditions were selected based on the minimum loss of NaOH and maximum PD (so that reactor volume required per ton of raw coal treatment can be minimized) along with the desired ...
The combined technical route of chemical separation, biochemical treatment, and depth treatment is commonly used to treat highly concentrated organic wastewater containing phenols from coal gasification in industry [3,4,5].The coal gasification wastewater contains concentrations of phenolic substances which will poison and inactivate the working flora in the biochemical treatment section.
An improved catalytic wet oxidation method for the disposal of excess activated sludge from a coal chemical wastewater treatment process by using the prepared CuCe/γAl2O3 catalyst was reported. The effects of catalyst dosage, reaction temperature and time, and initial oxygen pressure on the degradation of the sludge were investigated. The maximum removal rate of volatile suspended solids ...
It is a process that normally begins at the early stage of a mine site opening (European Commission, ... pulps with a low proportion of solids are used in the pumping of less dense tailings such as those from coal treatment (Department of Industry, Tourism and Resources, 2007). The consistency of the pulp depends on the type of tailings, their ...
The treatment process of the wastewater from fixedbed gasification is complex and the operation cost is high (Yang and Corsolini, 2019). Coal chemical projects consume a large quantity of water and produce a lot of wastewater, respectively (Chen et al., 2020). Most of the coal chemical projects are located in the northwest region of China ...
Coke (fuel) Raw coke. Coke is a grey, hard, and porous coalbased fuel with a high carbon content and few impurities, made by heating coal or oil in the absence of air—a destructive distillation process. It is an important industrial product, used mainly in iron ore smelting, but also as a fuel in stoves and forges when air pollution is a ...
The coal blended for coking passes through a microwave reaction cavity at a frequency of 300 MHz300 GHz for treatment. In this pretreatment process, the coal layer thickness and length of stay in the reaction cavity should be controlled, the sulphurcontaining gases within the cavity should be exported timely, and it should be ensured that ...
Cumulative effects and metabolic characteristics of aromatic compounds in microbial cells during the biochemical treatment process of coal chemical wastewater. Author links open overlay panel Lu Yang a, Yongjun Liu a b, Aining Zhang a ... This study aimed to investigate the effectiveness of a biochemical treatment system for coal chemical ...
The abovementioned four coal liquefaction residue treatment process schemes have the same process of fluidized pyrolysis reaction parts, and the material balance of the reaction is shown in Table 3. For a direct coal liquefaction plant with an oil output of 1 million tons/year, the byproduct coal liquefaction residue is about 700,000 tons/year.
The basic purpose of coal treatment for most uses to which coal was put, was to reduce the ash content of the coal but during the treatment process some of the sulfur was also removed. ... lowash coal) the Synthoil process of teh Bureau of Mines and the Hcoal process of Hydrocarbon Research Incorporated could be considered as likely process ...
According to the accurate model, the simulation for ZLD of fixedbed coal gasification wastewater treatment process is established, and this process is assessed from the perspective of thermodynamics, economy, and environment. The total energy consumption of ZLD process before optimization is × 10 8 W. The results of exergy analysis show ...
Recovery of platinum and synthesis of glassceramic from spent automotive catalyst via cotreatment process with coal fly ash Sun, Shuchen; Liu, Chuan; Xiao, Faxin; Tu, Ganfeng; Abstract. Publication: Journal of Material Cycles and Waste Management.
Coalassisted water electrolysis can be used to produce pure hydrogen under mild conditions and reduce the electricity consumption required for water electrolysis by 4060% while achieving clean utilization of coal. However, the kinetics for the process are very slow, and the mechanism has not yet been fully understood.
At the initial stage of steam treatment, the coal maintained a low temperature and a quite low thermal conductivity. The heat was transferred from the coal surface to the interior of the coal through heat conduction. ... T 2 spectra of lignite during the steam treatment process and at complete water saturation. Download : Download highres ...
A process and apparatus for treating coal to produce micronsize coal particles having high surface reactivity and a low level of ashforming impurities. The process involves grinding the coal in a substantially air tight fluid energy attrition mill to form a hydrophobic coalfraction and a hydrophilic impuritiesfraction, and separating the fractions by virtue of the impuritiesfraction's ...
The properties of the carbon materials obtained as the final product of coal tar pitch carbonization process are a consequence of the type of chemical and physical phenomena occurring through the process. A new simplified approach for modeling of the primary carbonization is presented to provide the semiquantitative knowledge about the process useful for improving the efficiency of the ...
The whole treatment process of CPW is shown in Fig. 1. The coal particles are introduced into the drying unit to provide steam for CLG and the remaining dry coal enters into the pyrolysis unit to produce pyrolysis gas and char. The CPW is generated during cooling and separation of pyrolysis gas.
The process may occur naturally during coal stockpiling for the weathering (Aich et al. 2019; Maloney et al. 1982) ... It is thus suggested to operate the thermal treatment for preparation of coalderived ACs at the heating rate range 2040 °C (Tables and ).
In the process of coal gasification wastewater treatment, in order to achieve a better treatment effect, ozone oxidation, or catalytic ozone oxidation is often used in combination with biotechnology such as MBR and biological fluidized bed. The laboratory has studied the treatment effect of coaltogas wastewater by the combination of ...
In order to solve the problem of mine water treatment in the production process of coal mine enterprises, the source and characteristics of mine water are introduced, and the zero discharge technology of mine water is studied and applied in engineering, the zero discharge technology of mine water includes three stages: pretreatment, concentration and reduction, and evaporation and crystallization.
article{osti_, title = {Coal treatment process}, author = {Taylor, D W}, abstractNote = {A process and apparatus are disclosed for treating coal to produce micronsize coal particles having high surface reactivity and a low level of ashforming impurities. The process involves grinding the coal in a substantially air tight fluid energy attrition mill under controlled temperature ...
Utah. Plant manager Jon Finlinson at the coalfired Intermountain Power Plant outside Delta, Utah. (Luis Sinco / Los Angeles Times) PacifiCorp is a major player in Utah, too, operating the Hunter ...
Mining coal. Coal miners use large machines to remove coal from the earth. Many coal deposits, called coal beds or seams, are near the earth's surface, but others are deep mining methods allow coal miners to easily reach most of the nation's coal reserves and to produce about three times more coal in one hour than in 1978.
© DZCrusher - كل الحقوق محفوظة
