This paper briefly introduces various methods of coal desulfurization (physical desulphurization, chemical desulfurization, biological desulfurization, etc.) and analyzes some problems existing in each method. The principle and research process of friction electrostatic separation technology and high gradient magnetic separation technology in precombustion desulfurization technology are ...
Since the "Eleventh FiveYear Plan" period, the construction of flue gas desulfurization and denitrification facilities for coalfired power plants have been accelerated to control the emissions of sulfur dioxide (SO 2) and nitrogen oxides (NO X) and thus to address the issue of acid rain in to the goal of the "Thirteenth FiveYear Plan for Energy Saving and Emission ...
Fly ash, which is a solid waste from coal power plants, was used as a precursor to prepare a zeolitetype adsorbent. This fly ashbased zeolite (Gismondine) was active for desulfurization of a model feed of TH (500 ppm S) and BT (500 ppm S) with 43% and % sulfur removal efficiency [125]. Dolochar is a waste byproduct of the sponge iron ...
Solid Wastes. Nicholas P. Cheremisinoff, in Clean Electricity Through Advanced Coal Technologies, 2012 FlueGas Desulfurization Material. Fluegas desulfurization (FGD) material is a product of a process typically used for reducing SO 2 emissions from the exhaust gas system of a coalfired boiler. The physical nature of these materials varies from a wet sludge to a dry, powdered material ...
![Desulfurization of coal using four ionic liquids with [HSO4]−](/4695nlp/11.jpg)
The combined irradiation process of ultrasonic and microwave energy is observed to be the most effective for the beneficiation of highsulfur coal than the single process. The result showed a maximum of % and % ash (mineral matter) removal from the coal samples by microwave followed by an ultrasonic process.
A series of mesoporous xLayMn/KIT6 sorbents with different La/Mn atomic ratios were fabricated by a solgel method and their desulphurization properties in hot coal gas were investigated at 700 ...
According to the enlargement of fine particles by heterogeneous condensation and typical technology of wet flue gas desulphurization (WFGD) system, a novel process is proposed in this paper to remove fine particles from coalfired flue gas in WFGD system which use limestone as desulfurizer.
Coal is a nonrenewable fossil fuel and has been used as a main source of energy for centuries. Fossil fuels are utilized as not only for energy production but also the raw material as the main inputs for many industries such as paint, plastic, pharmaceutical, cosmetics, iron steel and aluminum production (Prayuenyong 2002).However, the use of coal, both the energy source of some of the major ...
Within 30 days, it was possible to reduce the pyrite sulfur content in coal samples by 8595% and the total sulfur content by 3151%. The microorganisms were cultured on a solid nutrient medium, the process of coal desulfurization proceeded at a temperature of 30°C, the pulp density was 10%, and the coal particle size was 74 μm.
Coal combustion products ( CCP 's) are the inorganic residues that remain after pulverized coal is burned. Coarse particles (bottom ash and boiler slag) settle to the bottom of the combustion chamber), and the fine portion (fly ash, fig. 1) is removed from the flue gas by electrostatic precipitators or other gasscrubbing systems. Figure 1.
Nonetheless, it is the preferred process for coalfired electric utility power plants burning coal due to the low cost of limestone and SO 2 control efficiencies from 90% up to 98% (Schnelle, 2002). SemiDry Systems Semidry systems, or spray dryers, inject an aqueous sorbent slurry similar to a wet system, however,
How to reduce the energy consumption of the rotary kilnelectric furnace (RKEF) process has become an important issue for the stainless steel industry. The aim of this study is to reduce the energy consumption of ferronickel production from saprolite nickel laterite in the RKEF process. The effects of the slag binary basicity, FeO content, and Cr2O3 content on the melting temperature and ...
The flue gas desulfurization wastewater is highly saline and has too many refractory pollutants to be recycled during the desulfurization process of the coalfired heating plant. Given that waste heat is abundant in coalfired heating plants, a thermal ...
The coal hydrogen production process requires hightemperature steam as a reactant. Coalfired boilers are usually used to provide hightemperature steam. The ammoniabased desulphurization process is an effective technology to remove SO2 in the coalfired flue gas. However, the mass transfer coefficient of SO2 in such an engineered process is not readily available in the literature. In this ...
Therefore, exhaust gas from burning process with high sulphur coal must be treated by installations for removal of SO 2. Due to the high cost of these installations and under the increasing limitations of SO 2 emissions, predesulphurization of coal is essential.
Optimization Mechanism of Permeability Response Behavior of Fine Coal. The absorption process of microwave energy in fine coal is a kind of electromagnetic response process. The electromagnetic wave energy was converted into heat energy so that the microwave energy would be absorbed through dielectric and magnetic losses.
Study on Ammonium Sulfate Crystallization in the Ammonium Desulphurization Process in a Coalbased Power Plant in the Petrochemical Industry. Energy Sources, Part A: Recov Util Env Effects (2011) Yalin et al. Evaporating crystallization of ammonium sulfate byproduct of ammoniabased desulphurization process.
The flue gas desulfurization process in coalfired power plants is energy and resourceintensive but the ecoefficiency of this process has scarcely been considered. Given the fluctuating unit load and complex desulfurization mechanism, optimizing the desulfurization system based on the traditional mechanistic model poses a great challenge. In this regard, the present study optimized the eco ...
For the coal pyrolysis process, unstable sulfur compounds will decompose, generate sulfur radicals and release as sulfurcontaining gases, this becomes the main pathway for sulfur removal. Coal properties, minerals and sulfur forms in coal, and pyrolysis conditions such as temperature, atmosphere, and the mass transfer, are the main factors ...
Technologies for desulphurisation and others cleaning process from coal have several advantages and disadvantages (Saikia et al. Citation 2016; Wilcox et al ... Singh,, A. Kumar, Singh, et al. 2018. "Bacterial Desulphurization of lowRank Coal: A Case Study of Eocene Lignite of Western Rajasthan, India." Energy Sources, Part A ...
Most of the effective coal desulfurization techniques are based on chemical methods. Main desulfurization methods are chemical desulfurization, leaching, extraction, flotation, oxydesulfurization and biodesulfurization. The alkaline desulfurization is more effective in removing the pyritic sulfur from the coal, which is the less abundant form ...
Coal combustion is the largest single source of sulfur oxide pollution. Treatment of some major representative coals with aqueous ferric solution removes 40 to 75 percent of the sulfur content through near quantitative oxidation of the pyritic sulfur contained in the coal matrix. Elemental sulfur and iron sulfate are recovered as products ...
An anodic electrolytic oxidation desulphurization experiment was carried out on the liquefaction residue of the byproduct of a coaltoliquid enterprise in the slurry state. An electrochemical test and material characterization of raw materials before and after electrolysis showed that electrolytic oxidation can desulfurize the liquefaction ...
In the process of coal mining, prevention and control of water hazard is essential. It is the precondition for water hazard control to detect and determine the distribution of underground waterconducting channels. In urban environments, traditional methods such as active source seismic exploration and transient electromagnetic exploration commonly used in the field are difficult to carry out ...
article{osti_, title = {Coal desulfurization}, author = {Meyers, R A and Van Nice, L J and Santy, M J}, abstractNote = {The Meyers process of removing pyritic sulfur from coal chemically before it is burned is presented. The process involves the treatment of crushed coal with an aqueous leaching solution of ferric sulfate which reacts with the coal pyrites to yield soluable ferrous ...
© DZCrusher - كل الحقوق محفوظة
